1. IDENTIFICATION OF THE PREPARATION AND THE COMPANY
PRODUCT NAME: Tank cleaner
COMPANY IDENTIFICATON: Hidroshimi Farhang Aryana Co. Unit 16 , No. 217, kalhor St , Navvab St , TehranEMERGENCY TELEPHON NUMBER: +9821 66947522 – 66947491 – 66948831
2. COMPOSITION/ INFORMATION ON INGREDIENTS
CHEMICAL DESCRIPTION:
Hydrocarbon solvent, Surfactants
HAZARDOUS INGREDIENTS :
CAS NO EINECS NO. CHEMICAL NAME wt% SYMBOL R-PHRASES
Mixture Mixture Hydrocarbon solvent 80-100 Xn 65
3. HAZARDS IDENTIFICATION
HUMAN HEALTH HAZARDS - ACUTE:
INHALATION:
May cause irritation of mucous membranes. May cause headache and dizziness. Component of the product may affect the nervous system.
SKIN CONTACT:
Can cause mild irritation
EYE CONTACT:
Can cause mild irritation
INGESTION:
Harmful: may cause lung damage if swallowed. There may be irritation to the gastro-intestinal tract with nausea and vomiting. Can cause chemical pneumonia if aspirated in to lunge following ingestion.
HUMAN HEALTH HAZARDS- CHRONIC:
Prolonged/frequent skin contact may cause dermatitis.
ENVIRONMENTAL HAZARDS
None known .
PHYSICAL AND CHEMICAL HAZARDS :
Flash point 72
4. FIRST-AID MEASURE
INHALATION:
Remove to fresh air , rest, treat symptomatically .obtain medical attention.
SKIN CONTACT:
Remove contaminated clothing. wash off affected area immediately with plenty of water.
EYE CONTACT:
Immediately gently irrigate with clean water for at least 15 minutes. Move eyeball and keep eyelids wide open and apart whilst irrigating. obtain medical attention
INGESTION:
Do not induce vomiting: contains petroleum distillate and/or aromatic solvents. If conscious washout mouth and give one pint of water to drink Obtain medical attention
ADDITIONAL:
If unconscious do not give anything by mouth, place in the recovery position, check breathing and pulse. If necessary give artificial respiration.
5. FIRE-FIGHTING MEASURES
EXTINGUISHING MEDIA :
Water spray, foam, dry powder, carbon dioxide.
UNSUITABLE EXTINGUISHING MEDIA:
Do not use water jet.
FIRE AND EXPLOSION HAZARD:Oxides of nitrogen. oxides of sulfur, oxide of carbon (under fire conditions)
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE FIGHTING:
In case of fire, wear a full face positive- pressure self contained breathing apparatus and protective suit. Water mist may be used to cool closed container.
6.ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS :
Remove sources of ignition. Ensure adequate ventilation. Wear organic vapor respirator if Ventilation is inadequate. Wear chemical resistant apron, chemical splash goggles, impervious gloves and welling to boots.
ENVIRONMENTAL PRECAUTIONS :
Do not allow to enter sewers or water courses. if spillage does enter sewers or water courses, immediately inform the appropriate water authorities
METHODS FOR CLEANING UP:
Contain and absorb with sand or vermiculite and mix well. Collect up and remove to a safe place until disposal. Wash site of spillage thoroughly with water and detergent. Assistance can obtained from waste disposal companies.
7. HANDLING AND STORAGE
HANDLING:
Avoid contact with skin and eyes. If clothing is contaminated, remove clothing and thoroughly
wash the affected area. Launder contaminated clothing before reuse. Ensure adequate ventilation, No smoking. Avoid use of rubber. Spraying-spraying can lead to high solvent vapor concentrations. Wear organic vapors / mist respirator when spray cleaning large areas or if spray
MATERIAL SAFETY DATA SHEET
TANK CLEANER
cleaning for an appreciable length of time.
STORAGE CONDITIONS :
Keep container tightly closed in a cool, well- ventilated place. Connections must be grounded to avoid electrical charges. Store away from heat and sources of ignition. store separately from oxidizers. Storage for more than two years is not recommended.
8. EXPOSIN CONTROL/PERSONAL PROTECTION
OCCUPATIONAL EXPOSURE LIMITS
NATIONAL REGULATIONS UK
Total Hydrocarbons : recommendation 100 ppm (TWA)
ENGINEERING MEASURES
Local exhaust ventilation if necessary to control airborne levels below the exposure guidelines.
RESPIRATORY PROTECTION
Wear organic vapor respirator ventilation is inadequate.
HAND PROTECTION :
PVC gloves.
SKIN PROTECTION :
Not normally needed . Apron and boots (if skin contact is likely).
EYE PROTECTION :
chemical splash goggles.
HYGIENE RECOMMENDATIONS :
keep an eye wash fountain available
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM : Liquid
COLOUR: Straw
ODOUR : Aromatic
VALUE UNIT TEST METHO
BOILING POINT : NE
MELTING POINT: NA
FLASH POINT : >64 ْC SET A
(typically 72)
AUTOFLAMMABILITY: 420 ْ C
EXPLOSION LIMITS : lower 1.0%
upper6.0
VAPOR PRESSURE 20ْC 0.7 mbar
RELATIVE DENSITY : @20ْC 0.86-0.
88
SOLUBILITY IN WATER : Insoluble
PH NA
OCTANOL/ WATER COEFFICIENT : NE
VISCOSITY NE
BULK DENSITY : NE
FREEZING POINT : NE
POUR POINT : NEAbbreviation : NE= not evaluated, NA= not applicable, NR =not relevant
10. STABILITY AND REACTIVITY
STABILITY:
Stable under ambient conditions .
CONDITION TO AVOID:
Heat and sources of ignition including static discharges.
MATERIALS TO AVOIDOxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS :
Oxides of nitrogen oxides of sulfur oxides of carbon ( under fire conditions).
11. TOXICOLOGICAL INFORMATION
ACUTE TOXICITY DATA:
ACUTE LETHALITY VALUES:
No data available.
PRIMARY (DRAIZE TEST) SKIN/EYE
No data available.
SENSITIZATION:
No data available.
CHRONIC TOXICITY DATA:
No data available.
12. ECOLOGICAL INFORMATION
PERSISTENCY AND DEGRADATION:
No data available.
MOBILITY AND BIOACCUMULATION POTENTIAL:
No data available.
ECOTOXICOLOGICAL EFFECTS:
No data available.
13. DISPOSALCONSIDERATION
Via authorized contractor.
NATIONAL REGULATIONS UK
Complete incineration. In accordance with the Environmental Protection (Duty of care) Regulations 1991.
14. TRANSPORT INFORMATION
Class: Not regulated
15. REGULATORY INFORMATION
EC CLASSIFICATION:
HAZARD SYMBOL: Xn, HARMFUL
Xn, Harmful
Contains: Hydrocarbon solvent
RISK PHRASES:
R65 HARMFUL: may cause lung damage if swallowed.
SAFETY PHRASES:
S16 keep away from sources of ignition - No smoking. S24/25 Avoid Contact with skin and eyes.
S23 do not breathe vapors. S37/ 39 Wear Suitable gloves and eye/ face protection.
S62 if swallowed, do not induce Vomiting: seek medical advice immediately and show this container or label...
NATIONAL REGULATIONS UKCOSHH regulations apply. A precaution card is available and shouldBe displayed wherever this product is used and stored (REF.ASP).
16. OTHER INFORMATION
< قبلی | بعدی > |
---|